kubota l3400 won't start

The Shuttle Shift lever is stuck in the middle- it will not go into H/L/Reverse. Removed the solenoid and the tractor started, had to restrict airflow since the fuel solenoid was not connected.. I disconnected the two wires and plugged them into themselves and it started right away now it doesn't turn over at all. Check that the fuel shutoff solenoid is getting voltage before you go blaming the pump. Or maybe one of the PTOs are engaged? It may not display this or other websites correctly. If the problem does not solve yet, replace the fuel filter. Last week i got it out to pull a small tree and did great, put it back under the car port, came back the next day, started right up, drove about 50feet and quit, the engine turns over fine, but won't fire. Fuel flow issues are the most common reason for Kubota L3400 to stop working after running for a while. Unfortunately, not all tractor is perfect. But since your relays may not even click. JavaScript is disabled. You must log in or register to reply here. THe tractor will turn over but will not start. You can find it by following the fuel line back from the injection pump and the first thing you run into with wires is likely the lift pump. Kubota L3400 2006 will turn over but not start. 2023 TractorByNet.com | TractorByNet is a registered trademark of IMC Digital Universe, Inc. Other trademarks on this page are the property of their respective owners. I have problem but it is not the seat switch because the PTO continues to rotate whether I am on the seat or not. L3450DT-GST, Woods FEL, B7100 HSD, FEL, 60" SB, 743 Bobcat with V2203, and more. Kubota L3540 Won't Start. 1. if it is very low there, then by all means clean/repair the connections. We and our partners use cookies to Store and/or access information on a device. My pantleg occasionally catches the PTO lever on my L3400. You are using an out of date browser. Electrical System Check Electrical issues are among the most common reasons for engines not starting. The more I read about fuel solenoid the more I think my tractor non-run problem may be related to the fuel solenoid. From what you've posted thus far I'd leave the switch alone and start thinking the fuel shutoff solenoid (""it isn't clicking") is bad. if your Kubota tractor won't start watch this video - and try this first. It may not display this or other websites correctly. Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task. My Kubota l3400 tractor won't start. then put the leads on the clamp connections and read it there. Every 100 Hours. The fuel solenoid is not clicking when the key is turned. My 3400 HSt was new in dec 2006 and recently developed an intermittent starting problem, sometimes it would go etc.. My relatively new (71 hours) Kubota L3400 will not start. If your Kubota diesel engine does not start, begin by confirming that your electrical and fuel delivery systems are performing properly. Check the gear compartment if something like stone or dried mud had stuck there. You must log in or register to reply here. L3400 won't start - TractorByNet what I found was that not enough. Put the solenoid back on and it would start but then die immediately. if it is good, in other words it doesnt drop below about 11 volts. It generally happens when algae grow inside the fuel bowl. My Kubota L3400 is failing to start. When key is turned to the first The fuel solenoid is not engaging. Press question mark to learn the rest of the keyboard shortcuts. It may not display this or other websites correctly. It is hard to believe that two little wires control the whole contraption. Join us in searching for a Kubota diesel that will not start in the cold weather. You must log in or register to reply here. Mostly this creates the problem. I did try the fuel solenoid after I removed it and the rod does not move when starting the tractor. Once i had it running with the fuel solenoid out I had to get the tractor to turn off so I engaged it into gear and stood on the brake which shit the tractor off. My Kubota l3400 tractor won't start. People need to turn off the vehicle to operate it again. Thanks for the Kubota books site. I had two separate things affect starting on mine. Most times I get no click from the solenoid. You can face problems like the PTO not turning off even when the PTO lever is shifted to disengage. The dash lights stay strong and do not dim when the key is turned. L3200 Won't Start - Help!! | OrangeTractorTalks - Everything Kubota Removed the solenoid and the tractor started, had to restrict airflow since the fuel solenoid was not connected.. For a better experience, please enable JavaScript in your browser before proceeding. If the tractor starts off good, works for some time, and suddenly stops while in use, the most common reason is fuel starvation. 2023 TractorByNet.com | TractorByNet is a registered trademark of IMC Digital Universe, Inc. Other trademarks on this page are the property of their respective owners. Any help would be appreciated. For a better experience, please enable JavaScript in your browser before proceeding. It was fine then. What happens here is, that every other gear works fine and when you try to use that particular gear. Is the large wire on the starter near 12.6 volts? Closed the air vent cock. Checked battery, fuses, fuel and all are good. Put new solenoid on.no start. For a better experience, please enable JavaScript in your browser before proceeding. Kubota enthusiasts, hobbyists, and fans! You need a multimeter to start checking voltages. You will feel like this is a new vehicle you are running. L3400 won't start after trying to bleed fuel system. - OrangeTractorTalks Maybe try jumping the starter just to see if it turns over. So run the battery voltage test again. Established in 2009, we are the largest online community of Kubota tractor and equipment owners. That isn't an issue. Kubota Tractor won't startTry This - YouTube A battery starts with amps not volts. I got this tractor from my grand father that passed last year, about 2800 hours on it, my fathers friend helped tow it over and has been sitting beside the RV under our car part since, it has been ran a few times with no issues. This way you will get to know if the battery is dead. I followed the ignition procedure, indicator lights are fine, but when I turn the key I just get one beep followed by nothing, no clicks, nothing. If not try the second one. The first time it happened, it was 10 minutes before I figured it out. Or your fuel system needs bleed out so leave the injector line loose and crank for a while. It generally happens if there are any battery issues. Just a wild guess though. With the key in, turning it to the left does nothing (no lights on dash, etc), Turning the key to start does absolutely nothing, Turning the key to the spot to the right of off, but not all the way to start makes some sort of whining/humming sound like it's trying to do something but it can't. Overall, it increases the productivity of the tractor. Not starting, shutting off after some time, POT not turning on, and RPM slowing down are the common kubota l3400 problems. so look for bad grounds. If this is HST, rock your forward/reverse pedal back and forth while holding the key in the crank position. It appears to be in Neutral, but is not and will not start after I turned the switch off. Might even be your key switch which controls the solenoid. To fix this problem, you need to lean the fuel bowl first. 62. I had it going on Wednesday for about 20 to 30 minutes pushing snow, and then came back a few hours later to do some more work, and it wouldn't start. JavaScript is disabled. Here are the symptoms: It could still be the battery. Kubota L3400DT-IF 4 WD Tractor, Serial . You are using an out of date browser. Tight and clean them if necessary. Read somewhere that the fuel solenoid can cause the issue. Secondly, check and inspect the fuel filter. Charged the battery, Charged the battery, check the continuity on the fuses, traced power to the starter read more Chris (aka-Moose) Technician 363 satisfied customers 2015 Kubota 3350 w/cab . Press J to jump to the feed. L3400 won't start | OrangeTractorTalks - Everything Kubota 2023 TractorByNet.com | TractorByNet is a registered trademark of IMC Digital Universe, Inc. Other trademarks on this page are the property of their respective owners. If it is standard or Shuttle shift , there is a small micro-switch for the neutral of the Shuttle Shifter that does not make contact sometimes , I had to tweak mine slightly (micro-switch contact) once to get it to work correctly . For almost a Month I could not start the Kubota Tractor, come to find out after testing. But today when I turned the key to start, no click, only the sound of the starter turning. Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task. If it's got 12v at battery but no instrument panel lights, I'd suspect the switch. Fuel tank is half full. I followed the ignition procedure, indicator lights are fine, but when I turn the key I just get one beep followed by nothing, no clicks, nothing. You need to get a service book for this tractor with a wiring diagram. Was asked to take a look at this problem and was solved by installing Starter Relay Kit That he bought from john deer but will work on any tractor I would think. Ran the engine for 30 seconds and turned it off. It's diesel so it's probably either the injection pump or the lift pump. Please post back. I had it going on Wednesday for about 20 to 30 minutes pushing snow, and then came back a few hours later to do some more work, and it wouldn't start. What this does is, it pulls the fuel and takes it to the engine from the fuel tank. Yes, if the air was formed in the hydraulic system, it can be stopped completely. LOL. The issue is most likely another safety switch. Today went to start the tractor and it won't start. I figured I needed to bleed the system. PTO is also known as Power Take-Off enables the driver or operator to use the tractor for multiple uses. Established in 2009, we are the largest online community of Kubota tractor and equipment owners. I hope this article has given you a solid idea of where to start. Got up the next day, no start. And yes, some of them can be solved at home. . This sub Reddit is meant for everything and all things tractor and tractor related things. Turn the dial to the lowest setting in the resistance mode in the ohms portion of the meter. You need to get a tester light and follow the current. Does that include lube? You must log in or register to reply here. Check for voltage there and if not figure out why. I tried the solution proposed by crbr, rocking the transmission pedal - and it worked - made my day! You can also do a Biocide treatment and set it for overnight. Will it start challenge! Cold weather starting of Kubota equipment / Simple Trouble Shooting RudydaGoat 163 subscribers Subscribe Share 54K views 3 years ago Just on that one mission i learned lots. I always heard a click when when I turned on the key. For a better experience, please enable JavaScript in your browser before proceeding. Kubota Tractor Don't Start? 250 an hour?!? It doesn't even attempt to start. If it is the starter solenoid circuit that is preventing the starter, you can activate the starter at the starter, by bypassing the interlocking safety switches and activating it directly at the starter. Most failures to start with what you have described is from a faulty safety switch or just being out of adjustment. If the diesel fuel pours as it leaves the line, there may be something clogged in the line. Still no idea what to do next. Welcome. Both have to be in neutral. It is hard to believe that two little wires control the whole contraption. I am thinking maybe the ignition switch? Or if there is any faulty safety switch, it needs to replace too. But what is the problem which can appear in front of you? The ignition lights and dash lights turn on with the key on but the engine does not turn over. The issue would not be in your PTO switch if you have it plugged into each other. Definitely sounds like a fuel pump issue. Check the Deadman switch under the seat? I can't get back to it right now, but I'll have a chance to take another look at it Sunday afternoon and I'll try all your suggestions. If there is any water mixed with the oil then the engine can stall. For a better experience, please enable JavaScript in your browser before proceeding. The air cleaner can be clogged or an unadjusted engine valve can cause this problem. L3400 won't start. Safety switch. Help please! - OrangeTractorTalks The ignition lights and dash lights turn on with the key on but the engine does not turn over. Or bad battery connection(s). kubota L3500 cranks but won't start (EDIT) not 3500, L3400, and i think he said it was a 2008 model. Continue with Recommended Cookies. Many thanks. Battery fully charged, Curtis B., Technician 44,329 Curtis B., Technician 44,329 Satisfied Customers Try to understand what is the problem first. Today went to start the tractor and it won't start. Not the clamp connections, directly on the post's have someone try to start the tractor, anything less than 10.5 or 11 volts indicates either a bad battery (high internal resistance, or sulphated) or a shorted/draggy starter. Shutting of Suddenly Arter Working for a While. The dash lights come on, but when I turn the key all the way there is no click or response at all from the starter. shut down tractor in field, My tractor is suffering this now, but I do know where to look to get it back running. Though it is a renowned brand, unfortunately, there are some problems you may face. Firstly, check the fuel line. If the actual problem is this, it should be solved by this method. I am a little suspicious of the deadman switch, because lately when I've gotten off the tractor to move something or whatever, the engine will stop. If not then your solenoid could be bad if so then you have bigger issues that need deeper troubleshooting. Spray DW40 on the rubberboot and work the PTO shift back and forth. 5 Most Common Kubota L3400 Problems (Solutions Included) to know if the battery is good, put the lead directly on the battery post. Kubota has no idea what it is, and i'm not going to the place that gave me that quote, we jumped it for now. Two weeks ago is the last time I used my L3400. First, never use starting fluid in a diesel. The other was the switch that senses the neutral position of the hydro pedal. Do it for at least fine munities. The fuel solenoid shuts off fuel or engages linkage that controls fuel distribution. then put the leads on the clamp connections and read it there. 63. he kinda thinks the fuel pump went out, any way to test that, anything else i should do next, don't really know to much about tractors, but the only tractor place we have around here wants $900 to tow it, and $250 a hour to work on it. Kubota L3400 starter won't engage. They wanted 110ish for the shop manual for my L2501. The consent submitted will only be used for data processing originating from this website. Aug 9, 2021. follow that with all the safety switches in the path to engaging the start relay. Replaced the stop relay but still get same results. The other switches to look for are on the clutch pedal, on the range shifter if it is a standard shift or one just above the center of the floor board if it is a hydrostat. 64. Evacuator Valve. Sometimes it well run for a few seconds other times a few minutes. Disconnect the two small wires you will find in the PTO lever. Kubota L3540 Won't Start : r/kubota - reddit.com OrangeTractorTalks brings together Kubota enthusiasts from around the world, into one place, purpose built just for them. Getting fuel and hot battery. Why is my diesel engine stalling in Kubota L3400? Kubota L3400 died/won't start. I have a lead. Am I right? Best Evergreen Trees to Plant In New York, 10 Evergreen Trees to Plant in North Carolina, 5 Common Problems with John Deere 4120 (Solutions Included), Most Common Problems with John Deere 5045E (Solutions Added), 6 Most Common Problems with Massey Ferguson 240, 5 Most Common Problems with Bobcat T770 (Solutions Included), Most Common Problems with John Deere 750 (Solutions Added). I am going to talk about it elaborately in this article. Crack a line at an injector and see if you have fuel when cranking the engine. So, if there is any link of blockage in it, it can also create a problem. If you would like to change your settings or withdraw consent at any time, the link to do so is in our privacy policy accessible from our home page.. Kubota L3400 Manuals | ManualsLib Sounds like an obstruction or bad lift pump. Kubota L3400 starter wont engage. Battery fully charged, - JustAnswer Then I tried to continue mowing, but I only made it down the hill and the tractor stalled as I made the turn. .Sometimes it starts, then dies. I disconnected the two wires and plugged them into themselves and it started right away now it doesn't turn over at all. Battery is good. Did you run it out of fuel? L3400 won't start - help, please? - TractorByNet Thats where I would start, back on the battery. Thirdly, the problem can be in the fuel injector pump. or the starter engage, you need to know if it is the battery, or high resistance/ connection or something.

What Brings You Here Tinder, Illinois Wastewater Operator Ceu, Who Owns Anthony's Restaurant, Parkersburg, Wv Arrests Today, Beaver Patriot Thunder 425, Articles K